York SUNLINE MagnaDRY DR180 Installation Manual

GENERAL

RENEWAL PARTS

PRODUCT NOMENCLATURE

INSTALLATION

RIGGING AND HANDLING

DUCTWORK

CONDENSATE DRAIN

TYPICAL FIELD WIRING

THERMOSTAT

GAS PIPING

L.P. UNITS, TANKS AND PIPING

VENT AND COMBUSTION AIR HOODS

RELIEF DAMPER AND RAIN HOOD

ENTHALPY SETPOINT ADJUSTMENT

FOUR AND SIX POINT LOADS

PHYSICAL DATA

DR ELECTRICAL DATA - STANDARD DRIVE MOTOR W/O POWERED CONVENIENCE OUTLET

DR ELECTRICAL DATA - HIGH STATIC DRIVE MOTOR W/O POWERED CONVENIENCE OUTLET

DR ELECTRICAL DATA - LOW AIRFLOW DRIVE MOTOR W/O POWERED CONVENIENCE OUTLET

DR ELECTRICAL DATA - STANDARD DRIVE MOTOR WITH POWERED CONVENIENCE OUTLET

DR ELECTRICAL DATA - HIGH STATIC DRIVE MOTOR WITH POWERED CONVENIENCE OUTLET

DR ELECTRICAL DATA - LOW AIRFLOW DRIVE MOTOR WITH POWERED CONVENIENCE OUTLET

Utilities entry data

CFM, STATIC PRESSURE, AND POWER - ALTITUDE AND TEMPERATURE CORRECTIONS

FACTOR

STANDARD DRIVE (COOLING ONLY)

STANDARD DRIVE (GAS HEAT)

HIGH STATIC DRIVE (COOLING ONLY)

HIGH STATIC DRIVE (GAS HEAT)

STANDARD DRIVE

HIGH STATIC DRIVE

STATIC RESISTANCES

CHARGING CHART - 15 TON

PHASING

OPERATION

INTERMITTENT BLOWER

MOTORIZED OUTDOOR AIR DAMPERS

COMPRESSOR PROTECTION

REHEAT CONTROL BOARD

REHEAT CONTROLS - PART 1

OPERATIONS

HEATING OPERATION ERRORS

GAS HEATING SEQUENCE OF OPERATIONS

GAS HEATING OPERATION ERRORS

START-UP (COOLING)

START-UP (GAS HEAT)

PILOT CHECKOUT

TROUBLESHOOTING

GAS HEAT TROUBLESHOOTING GUIDE

UNIT FLASH CODES

REHEAT CONTROL BOARD FLASH CODES